Flour production from soybeans and corn is a promising strategy to increase their use as local ingredients in diverse food applications. In this study, local and improved varieties of soybean and corn seeds collected from Sumenep, Indonesia, were subjected to soaking pretreatments for 0, 24, 48, and 72 h prior to flour production. The resulting flours were characterized for their physicochemical and pasting properties and evaluated regarding their production cost. The results showed that variety and soaking time significantly affected the physicochemical properties of soybean and corn flours (p < 0.05). Longer soaking time reduced the bulk density and increased the whiteness of soybean and corn flours, except for the local corn variety, which was similar to the control (0 h). The yield increased for corn flour, while it decreased for soybean flour. Greater yield values were obtained for improved varieties relative to local varieties. The fat, protein, and amylose contents of both flours increased along with soaking time; however, ash and carbohydrate contents decreased. The pasting behaviors showed that soybean flours were hardly gelatinized, with no detectable peak viscosity at any soaking time. Conversely, corn flours gelatinized at a range of 72.35–75.65 ℃, with the highest values noted for 0-h soaking. Soaking for 24 h resulted in the highest peak viscosity, with values of 303.33 cP for the local Sumenep and 201.67 cP for HJ 21. A soaking pretreatment for 24 h was likely suitable for soybean seed, while corn required a longer (48 h) period. The economic analysis showed that home-scale production was feasible and profitable to be developed in the study area, with B/C ratios of 1.11–1.14 for soybean flour and 1.40–1.45 for corn flour.
Citation: Sri Satya Antarlina, Joko Susilo Utomo, Erliana Ginting, Dian Adi Anggraeni Elisabeth, Aniswatul Khamidah, Indrie Ambarsari, Heni Purwaningsih, Siti Dewi Indrasari, Ulyatu Fitrotin, Alit Pangestu, Fitri Nur Kayati, Yessy Anna Pratiwi, Sugeng Pondang Sugiharto, Hozin Aziz. Physicochemical characteristics, pasting behaviors and production cost of pre-soaked soybean and corn flours from local and improved varieties for supporting local food utilization[J]. AIMS Agriculture and Food, 2026, 11(1): 40-71. doi: 10.3934/agrfood.2026003
Flour production from soybeans and corn is a promising strategy to increase their use as local ingredients in diverse food applications. In this study, local and improved varieties of soybean and corn seeds collected from Sumenep, Indonesia, were subjected to soaking pretreatments for 0, 24, 48, and 72 h prior to flour production. The resulting flours were characterized for their physicochemical and pasting properties and evaluated regarding their production cost. The results showed that variety and soaking time significantly affected the physicochemical properties of soybean and corn flours (p < 0.05). Longer soaking time reduced the bulk density and increased the whiteness of soybean and corn flours, except for the local corn variety, which was similar to the control (0 h). The yield increased for corn flour, while it decreased for soybean flour. Greater yield values were obtained for improved varieties relative to local varieties. The fat, protein, and amylose contents of both flours increased along with soaking time; however, ash and carbohydrate contents decreased. The pasting behaviors showed that soybean flours were hardly gelatinized, with no detectable peak viscosity at any soaking time. Conversely, corn flours gelatinized at a range of 72.35–75.65 ℃, with the highest values noted for 0-h soaking. Soaking for 24 h resulted in the highest peak viscosity, with values of 303.33 cP for the local Sumenep and 201.67 cP for HJ 21. A soaking pretreatment for 24 h was likely suitable for soybean seed, while corn required a longer (48 h) period. The economic analysis showed that home-scale production was feasible and profitable to be developed in the study area, with B/C ratios of 1.11–1.14 for soybean flour and 1.40–1.45 for corn flour.
| [1] |
Rouf Shah T, Prasad K, Kumar P (2016) Maize‒A potential source of human nutrition and health: A review. Cogent Food & Agric 2: 1166995. https://doi.org/10.1080/23311932.2016.1166995 doi: 10.1080/23311932.2016.1166995
|
| [2] |
Siyuan S, Tong L, Liu R (2018) Corn phytochemicals and their health benefits. Food Sci Hum Wellness 7: 185–195. https://doi.org/10.1016/j.fshw.2018.09.003 doi: 10.1016/j.fshw.2018.09.003
|
| [3] |
Basson AR, Ahmed S, Almutairi R, et al. (2021) Regulation of intestinal inflammation by soybean and soy-derived compounds. Foods 10: 774. https://doi.org/10.3390/foods10040774 doi: 10.3390/foods10040774
|
| [4] |
Kim IS (2021) Current perspectives on the beneficial effects of soybean isoflavones and their metabolites for humans. Antioxidants 10: 1064. https://doi.org/10.3390/antiox10071064 doi: 10.3390/antiox10071064
|
| [5] | Ali W, Ahmad M, İftakhar F, et al. (2020). Nutritive potentials of soybean and its significance for humans health and animal production: A review. Eurasian J Food Sci Technol 4: 41‒53. |
| [6] |
Alaswad AA, Bo Song, Nathan WO, et al. (2021) Development of soybean experimental lines with enhanced protein and sulfur amino acid content. Plant Sci 308: 110912. https://doi.org/10.1016/j.plantsci.2021.110912 doi: 10.1016/j.plantsci.2021.110912
|
| [7] |
Kuswantoro H, Ginting E, Yusnawan E, et al. (2023) Agronomic performance, seed chemical composition, and bioactive components of selected Indonesian soybean genotypes (Glycine max [L.] Merr.). Open Agric 8: 20220229. https://doi.org/10.3390/agronomy10091315 doi: 10.3390/agronomy10091315
|
| [8] | Ginting E, Yulifianti R, Kuswantoro H, et al. (2018). Protein, fatty acid and isoflavone contents of soybean lines tolerant to acid soil. J Korean Soc Int Agric 30: 167–176. http://db.koreascholar.com/article.aspx?code = 357239 |
| [9] |
Yu JK, Moon YS (2021) Corn starch: Quality and quantity improvement for industrial uses. Plants 11: 92. https://doi.org/10.3390/plants11010092 doi: 10.3390/plants11010092
|
| [10] |
Oladapo AS, Adepeju AB, Akinyele AA, et al. (2017) The proximate, functional and anti‒nutritional properties of three selected varieties of maize (yellow, white and pop corn) flour. Int J Sci Eng Sci 1: 23‒26. https://doi.org/10.15580/gjas.2016.9.101516167 doi: 10.15580/gjas.2016.9.101516167
|
| [11] | Dewanto FA (2025) Pola Produksi dan Konsumsi Jagung Indonesia (Indonesian corn production and consumption patterns). Available from: https://www.beritadaerah.co.id/index.php/2025/01/05/pola‒produksi‒dan‒konsumsi‒jagung‒indonesia/. |
| [12] | BPS 2024a Luas panen dan produksi jagung di Indonesia pada tahun 2023 (Harvested area and maize production in Indonesia in 2023 (2025) Available from: https://www.bps.go.id/id/pressrelease/2024/03/01/2377/pada‒2023‒luas‒panen. |
| [13] | BPS 2024b Analisis produktivitas jagung dan kedelai di indonesia 2023 (hasil ubinan) (Analysis of maize and soybean productivity in Indonesia in 2023 based on crop cutting survey results) (2025) Available from: https://www.bps.go.id/id/publication/2024/08/30/e2e46d52a9cc9f78422f77ad/analisis‒produktivitas‒jagung‒dan‒kedelai‒di‒indonesia‒2023‒hasil‒survei‒ubinan‒.html. |
| [14] | Balitkabi (2016) Deskripsi Varietas Unggul Kacang‒kacangan dan Umbi‒umbian (Description of superior varieties of legumes and tubers). Balai Penelitian Tanaman Kacang‒kacangan dan Umbi‒umbian. Malang. |
| [15] | Balitkabi (2021) Deskripsi Varietas unggul Aneka Kacang dan Umbi (Description of superior varieties of legumes and tubers). Balai Penelitian Tanaman Aneka Kacang dan Umbi. Malang. |
| [16] | BPSI Tanaman Serealia (2024) Deskripsi Varietas Unggul Baru Jagung dan Sorgum (Description of new superior varieties of corn and sorghum). Balai Pengujian Standar Instrumen Tanaman Serealia. Maros. |
| [17] |
Ramadhani F, Surmaini E, Dariah A, et al. (2024) Multisource spatiotemporal analysis of cropping patterns on dry upland: A case study in Rubaru Sub‒district, Sumenep Regency. The Egypt J Remote Sens Space Sci 27: 403‒415. https://doi.org/10.1016/j.ejrs.2024.04.008 doi: 10.1016/j.ejrs.2024.04.008
|
| [18] |
Arifin Z, Tafakresnanto C (2019) Pengelolaan pola tanam berbasis kedelai dan jagung di lahan kering (Management of soybean- and maize-based cropping systems in dryland agroecosystems). Buletin Palawija 17: 83‒93. https://doi.org/10.21082/bulpa.v17n2.2019.p83-93 doi: 10.21082/bulpa.v17n2.2019.p83-93
|
| [19] | Ekawati I (2009) Prospek budidaya kedelai sistem organik di Kabupaten Sumenep (Prospects for organic soybean cultivation in Sumenep Regency). Agri‒Tek. Jurnal Penelitian Ilmu‒Ilmu Eksakta 10: 70‒77. |
| [20] | BPS Jawa Timur 2024 (2024) Indikator Pertanian Provinsi Jawa Timur 2023 (East Java Province Agricultural Indicators 2023) 12: 184. |
| [21] |
Amzeri A, Djunaedy AZMRASZ, Ardianzah D, et al. (2018) Uji daya hasil pendahuluan kandidat jagung hibrida Madura (Preliminary yield trial of Madura hybrid corn candidates). Agrovigor: Jurnal Agroekoteknologi 11: 120‒127. https://doi.org/10.21107/agrovigor.v11i2.5080 doi: 10.21107/agrovigor.v11i2.5080
|
| [22] |
Prasetyo DD, Fauziyah E (2020) Efisiensi ekonomi usahatani jagung lokal di Pulau Madura (Economic efficiency of local corn farming on Madura Island). Agriscience 1: 26‒38. https://doi.org/10.21107/agriscience.v1i1.7505 doi: 10.21107/agriscience.v1i1.7505
|
| [23] |
Wati HD, Ekawati I, Ratna P (2022) Keragaman Genetik dan Heritabilitas Karakter Komponen Hasil Jagung Varietas Lokal Sumenep (Genetic diversity and heritability of yield component characters of local corn varieties in Sumenep). Jurnal Pertanian Cemara 19: 85‒94. https://doi.org/10.24929/fp.v19i1.1985 doi: 10.24929/fp.v19i1.1985
|
| [24] | Jamilah IN, Suprapti I (2022) Analisis nilai tambah marning jagung lokal madura (Studi Kasus: UD. Sinar Murni Kecamatan Manding Kabupaten Sumenep) (Analysis of the added value of local Madurese corn (Case Study: UD. Sinar Murni, Manding District, Sumenep Regency)). Prosiding Seminar Nasional Hasil Penelitian Pertanian, Perikanan dan Kelautan 2(2021), Surabaya. Universitas Trunojoya, Bangkalan, 201‒207. Available from: https://ilmukelautan.trunojoyo.ac.id/wp‒content/uploads/2022/05/Jamilah‒dan‒Suprapti.pdf. |
| [25] | Hajar I (2024) Nasi Jagung Menjadi Menu Favorit Buka Puasa (Corn rice becomes a favorite menu for breaking the fast). Available from: https://www.rri.co.id/kuliner/599209/nasi‒jagung‒menjadi‒menu‒favorit‒buka‒puasa. |
| [26] | Ekawati SH (2024) "Durnang" Kuliner Khas Daerah Melegenda ("Durnang" legendary regional culinary specialty). Available from: https://rri.co.id/kuliner/731871/durnang‒kuliner‒khas‒daerah‒melegenda. |
| [27] |
Aziz F, Jansen IA, Liridla M (2020) Pengembangan home industry Tempe "Keraton" Desa Montorna. J Food Technol Agroindustry 2: 70‒78. https://doi.org/10.24929/jfta.v2i2.961 doi: 10.24929/jfta.v2i2.961
|
| [28] |
Hasanah H, Rum M (2023) Analisis nilai tambah dan strategi pengembangan industri rumah tangga tahu di Kecamatan Guluk‒Guluk, Kabupaten Sumenep (Analysis of added value and development strategies for the tofu home industry in Guluk-Guluk District, Sumenep Regency). Agriscience 3: 623‒637. https://doi.org/10.21107/agriscience.v3i3.15744 doi: 10.21107/agriscience.v3i3.15744
|
| [29] |
Manaf AHA, Hidayatullah N, Utami VK (2023) Pengembangan industri tahu skala rumah tangga menjadi tahu sutera Desa Jaddung Kecamatan Pragaan Kabupaten Sumenep Abdisuci. (Development of the household scale tofu industry into silken tofu in Jaddung Village, Pragaan District, Sumenep Abdisuci Regency) Jurnal Pengabdian dan Pemberdayaan Masyarakat 1: 42‒46. https://doi.org/10.59005/j-abdisuci.v1i1.92 doi: 10.59005/j-abdisuci.v1i1.92
|
| [30] | Roziyanto IE (2025) Cemilan unik, kacang kedelai goreng gurih dan renyah (Unique snack, savory and crispy fried soybeans). Available from: https://www.rri.co.id/sumenep/kuliner/1112902/cemilan‒unik‒kacang‒kedelai‒goreng‒gurih‒dan‒renyah. |
| [31] |
Firdaus MW, Fauziyah E (2020) Efisiensi ekonomi usahatani jagung hibrida di Pulau Madura. (Economic efficiency of hybrid corn farming on Madura Island). Agriscience 1: 74–87. https://doi.org/10.21107/agriscience.v1i1.7624 doi: 10.21107/agriscience.v1i1.7624
|
| [32] |
Arifin Z, Tafakresnanto C (2019) Pengelolaan Pola Tanam Berbasis Kedelai dan Jagung di Lahan Kering (Management of soybean and corn-based cropping patterns in dry land). Buletin Palawija 17: 83‒93. https://doi.org/10.21082/bulpa.v17n2.2019.p83-93 doi: 10.21082/bulpa.v17n2.2019.p83-93
|
| [33] |
Rahmaniyah F, Rum M (2020) Analisis Daya Saing Jagung Hibrida Unggul Madura MH‒3 di Kabupaten Bangkalan (Competitiveness analysis of the superior Madura hybrid maize MH-3 in Bangkalan Regency). Agrisience 1: 367‒382. https://doi.org/10.21107/agriscience.v1i2.8020 doi: 10.21107/agriscience.v1i2.8020
|
| [34] |
Krismawati A, Arifin Z, Hermanto C, et al. (2021) Application of biochar to improve maize performance on volcanic and sediment soil based parent materials in dry land. IOP Conference Series: Earth and Environmental Science 648: 012177. https://doi.org/10.1088/1755-1315/648/1/012177 doi: 10.1088/1755-1315/648/1/012177
|
| [35] |
Krishnan HB, Jez JM (2018) Review: The promise and limits for enhancing sulfur‒containing amino acid content of soybean seed. Plant Sci 272: 14‒21. https://doi.org/10.1016/j.plantsci.2018.03.030 doi: 10.1016/j.plantsci.2018.03.030
|
| [36] |
Zhao H, Shen C, Wu Z, et al. (2020) Comparison of wheat, soybean, rice, and pea protein properties for effective applications in food products. J Food Biochem 44: e13157. https://doi.org/10.1111/jfbc.13157 doi: 10.1111/jfbc.13157
|
| [37] |
Oyeyinka SA, Adebayo AI, Oyeyinka AT, et al. (2020) Flour functionality, physicochemical and sensory properties of steamed and baked maize meal enriched with defatted soybean. J Food Process Preserv 44: e14389. https://doi.org/10.1111/jfpp.14389 doi: 10.1111/jfpp.14389
|
| [38] |
Deshpande SD, Bal S (2001) Effect of soaking time and temperature on textural properties of soybean. J Texture Stud 32: 343‒347. https://doi.org/10.1111/j.1745‒4603.2001.tb01241.x doi: 10.1111/j.1745‒4603.2001.tb01241.x
|
| [39] |
Antarlina SS, Estiasih T, Zubaidah E, et al. (2021) The physicochemical properties of white sorghum (Sorghum bicolor L.) flour in various particle sizes by soaking the seeds before and after dehulling. Food Res 5: 129–143. https://doi.org/10.26656/fr.2017.5(3).541 doi: 10.26656/fr.2017.5(3).541
|
| [40] |
Teusink B, Molenaar D (2017) Systems biology of lactic acid bacteria: For food and thought. Curr Opin Syst Biol 6: 7‒13. https://doi.org/10.1016/j.coisb.2017.07.005 doi: 10.1016/j.coisb.2017.07.005
|
| [41] | Badan Pangan Nasional (2024) Peraturan Presiden (Perpres) Nomor 81 Tahun 2024 tentang Percepatan Penganekaragaman Pangan Berbasis Potensi Sumber Daya Lokal. Badan Pangan Nasional. Jakarta (Presidential Regulation (Perpres) Number 81 of 2024 concerning the Acceleration of Food Diversification Based on Local Resource Potential. National Food Agency. Jakarta). Available from: https://peraturan.bpk.go.id/Details/295850/perpres‒no‒81‒tahun‒2024. |
| [42] |
Ginting E, Elisabeth DAA, Khamidah A, et al. (2024) The nutritional and economic potential of tofu dreg (okara) and its utilization for high protein food products in Indonesia. J Agric Food Res 16: 101175. https://doi.org/10.1016/j.jafr.2024.101175 doi: 10.1016/j.jafr.2024.101175
|
| [43] |
Fauziah L, Anggraeni L, Latifah E, et al. (2023) Increased yield and quality of corn by inorganic fertilizers and utilization of corn as food to support food security. IOP Conference Series: Earth and Environmental Science 1253: 012129. https://doi.org/10.1088/1755-1315/1253/1/012129 doi: 10.1088/1755-1315/1253/1/012129
|
| [44] |
Khamidah A, Antarlina SS (2022) Corn flour substitution at pastry production. IOP Conference Series: Earth and Environmental Science 1107: 012058. https://doi.org/10.1088/1755-1315/1107/1/012058 doi: 10.1088/1755-1315/1107/1/012058
|
| [45] |
Fanzurna, CO, Taufik M (2020) Formulasi foodbars berbahan dasar tepung kulit pisang kepok dan tepung kedelai. Jurnal Bioindustri 2: 439‒452. https://doi.org/10.31326/jbio.v2i2.629.g345 doi: 10.31326/jbio.v2i2.629.g345
|
| [46] |
Aini N, Wijonarko G, Sustriawan B (2016) Sifat fisik, kimia, dan fungsional tepung jagung yang diproses melalui fermentasi (Physical, chemical, and functional properties of corn flour processed through fermentation). Agritech 36: 160‒169. https://doi.org/10.22146/agritech.12860 doi: 10.22146/agritech.12860
|
| [47] |
Ndukwu MC (2009) Determination of selected physical properties of Brachystegia eurycoma seeds. Res Agric Eng 55: 165‒169. https://doi.org/10.17221/14/2009-RAE doi: 10.17221/14/2009-RAE
|
| [48] |
Kaur M, Singh N (2007) Relationships between various functional, thermal and pasting properties of flours from different Indian black gram (Phaseolus mungo L.) cultivars. J Sci Food Agric 87: 974–984. https://doi.org/10.1002/jsfa.2789 doi: 10.1002/jsfa.2789
|
| [49] | Balamaceda EA, Kim MK, Franzen, et al. (1984) Protein functionality methodology standard test. In: Regenstein J (Ed.), Food Protein Chemistry: An Introduction for Food Scientist, Academic Press Inc. New York. |
| [50] | AACC (2010) Approved Methods of Analysis (11th ed.). Cereal & Grain Association. Available from: https://www.cerealsgrains.org/resources/Methods/Pages/default.aspx. |
| [51] | Juliano BO (1971) A simplified assay for milled‒rice amylose. Cereal Sci Today 16: 334–340. Available from: https://www.researchgate.net/publication/275886661. |
| [52] |
Gull A, Prasad K, Kumar P (2018) Nutritional, antioxidant, microstructural and pasting properties of functional pasta. J Saudi Soc Agric Sci 17: 147–153. https://doi.org/10.1016/j.jssas.2016.03.002 doi: 10.1016/j.jssas.2016.03.002
|
| [53] |
Collado LS, Corke H (1999) Heat moisture treatment effect on sweet potato starch differing in amylose content. Food Chem 65: 339‒346. https://doi.org/10.1016/S0308‒8146(98)00228‒3 doi: 10.1016/S0308‒8146(98)00228‒3
|
| [54] |
Coskuner Y, Karababa E (2007) Physical properties of coriander seeds (Coriandrum sativum L.). J Food Eng 80: 408–416. https://doi.org/10.1016/j.jfoodeng.2006.02.042 doi: 10.1016/j.jfoodeng.2006.02.042
|
| [55] |
Solomon WK, Zewdu AD (2009) Moisture‒dependent physical properties of niger (Guizoatia abyssinic Cass.) seed. Ind Crops Prod 29: 165‒170. https://doi.org/10.1016/j.indcrop.2008.04.018 doi: 10.1016/j.indcrop.2008.04.018
|
| [56] |
Atmaka W, Amanto BS (2010) Kajian karakterikstik fisikokimia tepung instan beberapa varietas jagung (Zea mays L.) (Study on the physicochemical characteristics of instant flour from several maize (Zea mays L.) varieties). Jurnal Teknologi Hasil Pertanian 3: 13‒20. https://doi.org/10.20961/jthp.v0i0.13614 doi: 10.20961/jthp.v0i0.13614
|
| [57] | Molenda M, Montros MD, Horabik J (2002) Mechanical properties of corn and soybean meal. Trans Am Soc Agric Eng 45: 1929–1936. |
| [58] | Soyoye BO, Ademosun OC, Agbetoye LAS (2018) Determination of some physical and mechanical properties of soybean and maize in relation to planter design. IGR J 20: 81–89. Available from: http://www.cigrjournal.org. |
| [59] |
Kruszelnicka W, Chen Z, Ambrose K (2022) Moisture-dependent physical-mechanical properties of maize, rice, and soybeans as related to handling and processing. Materials 15: 8729. https://doi.org/10.3390/ma15248729 doi: 10.3390/ma15248729
|
| [60] |
Da Silva AR, Leão‐Araújo ÉF, Rezende BR, et al. (2018) Modeling the three phases of the soaking kinetics of seeds. Agron J 110: 164‒170. https://doi.org/10.2134/agronj2017.07.0373 doi: 10.2134/agronj2017.07.0373
|
| [61] |
Besharati B, Lak A, Ghaffari H, et al. (2021) Development of a model to estimate moisture contents based on physical properties and capacitance of seeds. Sens Actuators A: Phys 318: 112513. https://doi.org/10.1016/j.sna.2020.112513 doi: 10.1016/j.sna.2020.112513
|
| [62] |
Altuntas E, Demirtola H (2007) Effect of moisture content on physical properties of some grain legume seeds. N Z J Crop Hortic Sci 35: 423‒433. https://doi.org/10.1080/01140670709510210 doi: 10.1080/01140670709510210
|
| [63] |
Karimi M, Kheiralipour K, Tabatabaeefar A, et al. (2009). The effect of moisture content on physical properties of wheat. Pak J Nutr 8: 90‒95. https://doi.org/10.3923/pjn.2009.90.95 doi: 10.3923/pjn.2009.90.95
|
| [64] |
Gunathilake DMCC, Bhat J, Singh IR, et al. (2019). Dynamics of the physical properties of soybean during storage under tropical condition. Legume Res 42: 370–374. https://doi.org/10.18805/LR-447 doi: 10.18805/LR-447
|
| [65] |
Cabañas-Ojeda JA, Nicolás JJ, Mejia-Abaunza, et al. (2023) Corn kernel hardness and drying temperature affect particle size post-hammer-milling and pellet quality in broiler and swine diets. Anim Feed Sci Technol 304: 115744. https://doi.org/10.1016/j.psj.2021.101395 doi: 10.1016/j.psj.2021.101395
|
| [66] |
Siddique AB, Wright D (2003) Effects of different seed drying methods on moisture percentage and seed quality (viability and vigour) of pea seeds (Pisum sativum L.). J Agron 2: 201‒208. https://doi.org/10.3923/ajps.2003.978.982 doi: 10.3923/ajps.2003.978.982
|
| [67] |
Song Y, Ndolo V, Fu BX, et al. (2021) Effect of processing on bioaccessibility of carotenoids from orange maize products. Int J Food Sci Technol 56: 3299‒3310. https://doi.org/10.1111/ijfs.15038 doi: 10.1111/ijfs.15038
|
| [68] | Reykdal Ó (2018) Drying and storing of harvested grain a review of methods. Skýrsla Matís 2018: 05‒18. |
| [69] |
Widowati S (2012) Keunggulan Jagung QPM (Quality Protein Maize) dan Potensi Pemanfaatannya dalam Meningkatkan Status Gizi (The advantage of quality protein maize and the potent of its utilization in improving nutritional status). Jurnal Pangan 21: 171‒184. https://doi.org/10.33964/jp.v21i2.127 doi: 10.33964/jp.v21i2.127
|
| [70] |
Ezeokeke CT, Onuoha AB (2016) Nutrient composition of cereal (maize), legume (soybean) and fruit (banana) as a complementary food for older infants and their sensory assessment. J Food Sci Eng 6: 139–148. https://doi.org/10.17265/2159-5828/2016.01.004 doi: 10.17265/2159-5828/2016.01.004
|
| [71] | Jahreis G, Brese M, Leiterer M, et al. (2016) Legume flours: Nutritionally important sources of protein and dietary fiber. Ernahrungs Umschau 63: 36–42. |
| [72] |
Zhang Q, Sun T, Wang J, et al. (2023) Genome-wide association study and high-quality gene mining related to soybean protein and fat. BMC Genomics 24: 596. https://doi.org/10.1186/s12864-023-09687-6 doi: 10.1186/s12864-023-09687-6
|
| [73] |
Chaudhary DP, Sapna MS, Mandhania S, et al. (2012) Inter-relationship among nutritional quality parameters of maize (Zea mays) genotypes. Indian J Agric Sci 82: 681. https://doi.org/10.56093/ijas.v82i8.23049 doi: 10.56093/ijas.v82i8.23049
|
| [74] |
Guan X, Zhong X, Lu Y, et al. (2021) Changes of soybean protein during tofu processing. Foods 10: 1594. https://doi.org/10.3390/foods10071594 doi: 10.3390/foods10071594
|
| [75] |
Ntso ASA, Njintang YN, Mbofung CMF (2017) Physicochemical and pasting properties of maize flour as a function of the interactive effect of natural-fermentation and roasting. J Food Meas Charact 11: 451‒459. https://doi.org/10.1007/s11694-016-9413-1 doi: 10.1007/s11694-016-9413-1
|
| [76] | Ciabotti S, Silva ACBB, Juhasz ACP, et al. (2016) Chemical composition, protein profile, and isoflavones content in soybean genotypes with different seed coat colors. Int Food Res J 23: 621‒629. Available from: http://www.ifrj.upm.edu.my/23%20(02)%202016/(23).pdf. |
| [77] |
Wang S, Wang J, Yu J, et al. (2014) A comparative study of annealing of waxy, normal and high-amylose maize starches: The role of amylose molecules. Food Chem 164: 332‒338. https://doi.org/10.1016/j.foodchem.2014.05.055 doi: 10.1016/j.foodchem.2014.05.055
|
| [78] | Suarni S, Firmansyah IU, Aqil M (2013) Keragaman mutu pati beberapa varietas jagung (Variability in starch quality among several maize varieties). Jurnal Penelitian Pertanian Tanaman Pangan 32: 124615. |
| [79] |
Wardhani APK, Wirnas D (2024) Keragaman genetik karakter agronomi dan amilosa populasi sorgum F3 hasil persilangan Pulut 3 x Soraya 3 (Genetic variability of agronomic traits and amylose content in the F3 sorghum population derived from the cross Pulut 3 × Soraya 3). Buletin Agrohorti 12: 52‒59. https://doi.org/10.29244/agrob.v12i1.53055 doi: 10.29244/agrob.v12i1.53055
|
| [80] |
Sayar S, Turhan M, Köksel H (2011) Solid loss during water absorption of chickpea (Cicer Arietinum L.). J Food Proc Eng 34: 1172‒1186. https://doi.org/10.1111/j.1745-4530.2009.00409.x doi: 10.1111/j.1745-4530.2009.00409.x
|
| [81] |
Coffigniez F, Rychlik M, Sanier C, et al. (2019) Localization and modeling of reaction and diffusion to explain folate behavior during soaking of cowpea. J Food Eng 253: 49–58. https://doi.org/10.1016/j.jfoodeng.2019.02.012 doi: 10.1016/j.jfoodeng.2019.02.012
|
| [82] |
Bayram M, Kaya A, Öner MD (2004) Changes in properties of soaking water during production of soy-bulgur. J Food Eng 61: 221‒230. https://doi.org/10.1016/S0260-8774(03)00094-3 doi: 10.1016/S0260-8774(03)00094-3
|
| [83] |
Kajihausa OE, Fasasi RA, Atolagbe YM (2014) Effect of different soaking time and boiling on the proximate composition and functional properties of sprouted sesame seed flour. Niger Food J 32: 8‒15. https://doi.org/10.1016/S0189-7241(15)30112-0 doi: 10.1016/S0189-7241(15)30112-0
|
| [84] | Princewill OP, Ezinne OE (2014) The effect of soaking time on some engineering properties of brown‒speckled African yam bean. Int J Eng Technol 4: 700‒708. |
| [85] |
Joshi AU, Liu C, Sathe SK (2015) Functional properties of select seed flours. LWT-Food Sci Technol 60: 325‒331. https://doi.org/10.1016/j.lwt.2014.08.038 doi: 10.1016/j.lwt.2014.08.038
|
| [86] |
Mukherjee R, Chakraborty R, Dutta A (2019) Soaking of soybean meal: Evaluation of physicochemical properties and kinetic studies. Journal of Food Measurement and Characterization: 13,390‒403. DOI:10.1007/s11694‒018‒9954‒6 doi: 10.1007/s11694‒018‒9954‒6
|
| [87] |
Mazi BG, Yıldız D, Barutçu MI (2023) Influence of different soaking and drying treatments on anti‒nutritional composition and technological characteristics of red and green lentil (Lens culinaris Medik.) flour. J Food Meas Charact 17: 3625‒3643. https://doi.org/10.1016/j.foodchem.2024.139293 doi: 10.1016/j.foodchem.2024.139293
|
| [88] |
Suri DJ, Tanumihardjo SA (2016) Effects of different processing methods on the micronutrient and phytochemical contents of maize: From A to Z. Compr Rev Food Sci Food Saf 15: 912‒926. https://doi.org/10.1111/1541‒4337.12216 doi: 10.1111/1541‒4337.12216
|
| [89] |
Li S, Tayie FA, Young MF, et al. (2007) Retention of provitamin A carotenoids in high β-carotene maize (Zea mays) during traditional African household processing. J Agric Food Chem 55: 10744‒10750. https://doi.org/10.1021/jf071815v doi: 10.1021/jf071815v
|
| [90] |
Cho KM, Ha TJ, Lee YB, et al. (2013) Soluble phenolics and antioxidant properties of soybean (Glycine max L.) cultivars with varying seed coat colours. J Funct Foods 5: 1065‒1076. https://doi.org/10.1016/j.jff.2013.03.002 doi: 10.1016/j.jff.2013.03.002
|
| [91] |
Afify AEMM, El Beltagi HS, Abd El Salam SM, et al. (2012) Biochemical changes in phenols, flavonoids, tannins, vitamin E, β-carotene and antioxidant activity during soaking of three white sorghum varieties. Asian Pac J Trop Biomed 2: 203‒209. https://doi.org/10.1016/S2221‒1691(12)60042‒2 doi: 10.1016/S2221‒1691(12)60042‒2
|
| [92] |
Rani H, Zulfahmi Z, Widodo YR (2013) Optimasi proses pembuatan bubuk (tepung) kedelai (Process optimization for the production of soybean powder (flour)). Jurnal Penelitian Pertanian Terapan 13: 188‒196. https://doi.org/10.25181/jppt.v13i3.187 doi: 10.25181/jppt.v13i3.187
|
| [93] | Gozalli M, Nurhayati N (2015) Karateristik tepung kedelai dari jenis impor dan lokal (varietas Anjasmoro dan Baluran) dengan perlakuan perebusan dan tanpa perebusan (Characteristics of imported and local soybean flour (Anjasmoro and Baluran varieties) with boiling and non-boiling treatments). Jurnal Agroteknologi 9: 191‒200. |
| [94] | Aini N, Hariyadi P, Muchtadi TR, et al. (2010) Hubungan antara waktu fermentasi grits jagung dengan sifat gelatinisasi tepung jagung putih yang dipengaruhi ukuran partikel (The relationship between the fermentation time of corn grits and the gelatinization properties of white corn flour as influenced by particle size). Jurnal Teknologi dan Industri Pangan 21: 18‒24. https://journal.ipb.ac.id/index.php/jtip/article/view/2450 |
| [95] |
Singh N, Bedi R, Garg R, et al. (2009) Physico–chemical, thermal and pasting properties of fractions obtained during three successive reduction milling of different corn types. Food Chem 113: 71‒77. https://doi.org/10.1016/j.foodchem.2008.07.023 doi: 10.1016/j.foodchem.2008.07.023
|
| [96] |
Wang HL, Swain EW, Hesseltine CW, et al. (1979) Hydration of whole soybeans affects solids losses and cooking quality. J Food Sci 44: 1510‒1513. https://doi.org/10.1111/j.1365-2621.1979.tb06474.x doi: 10.1111/j.1365-2621.1979.tb06474.x
|
| [97] |
El Safy F, Salem R, Ensaf Mukhtar YY (2013) The impact of soaking and germination on chemical composition, carbohydrate fractions, digestibility, antinutritional factors and minerals content of some legumes and cereals grain seeds. Alexandria Sci Exch J 34: 499‒513. https://doi.org/10.21608/asejaiqjsae.2013.3112 doi: 10.21608/asejaiqjsae.2013.3112
|
| [98] |
Agume ASN, Njintang NY, Mbofung CMF (2017) Effect of soaking and roasting on the physicochemical and pasting properties of soybean flour. Foods 6: 12. https://doi.org/10.3390/foods6020012 doi: 10.3390/foods6020012
|
| [99] |
Apaliya MT, Kwaw E, Osae R, et al. (2024) Effect of different drying methods on the rehydration kinetics, physiochemical and functional properties of unripe plantain (Musa parasidiaca) flour. Food Chem Adv 4: 100610. https://doi.org/10.1016/j.focha.2024.100610 doi: 10.1016/j.focha.2024.100610
|
| [100] | BSN 2011 Standar Mutu Tepung Kedelai (SNI 7612: 2011) (Soybean Flour Quality Standards (SNI 7612: 2011). Badan Standarisasi Nasional. Jakarta. |
| [101] | BSN 2020 Standar Mutu Tepung Tepung Jagung (SNI 3727: 2020) (Corn Flour Quality Standard (SNI 3727: 2020)). Badan Standarisasi Nasional. Jakarta. |
| [102] |
Suriya M, Baranwal G, Bashir M, et al. (2016) Influence of blanching and drying methods on molecular structure and functional properties of elephant foot yam (Amorphophallus paeoniifolius) flour. LWT-Food Sci Technol 68: 235‒243. https://doi.org/10.1016/j.lwt.2015.11.060 doi: 10.1016/j.lwt.2015.11.060
|
| [103] | Kumari S, Krishnan, V, Jolly M, et al. (2014) In vivo bioavailability of essential minerals and phytase activity during soaking and germination in soybean (Glycine max L.). Aust J Crop Sci 8: 1168‒1174. |
| [104] |
Qin P, Wang T, Luo Y (2022) A review on plant-based proteins from soybean: Health benefits and soy product development. J Agric Food Res 7: 100265. https://doi.org/10.1016/j.jafr.2021.100265 doi: 10.1016/j.jafr.2021.100265
|
| [105] |
Samofalova LA, Donskaya MV (2021) Study of the effect of soybean and chickpea seeds watering on protein complex solubility. IOP Conference Series: Earth and Environmental Science 640: 022076. https://doi:10.1088/1755‒1315/640/2/022076 doi: 10.1088/1755‒1315/640/2/022076
|
| [106] | Arifin R, Dewanti-Hariyadi R, Hariyadi P, et al. (2014) Profile of microorganisms and amylose content of white corn flours of two local varieties as affected by fermentation process. IPCBEE 77: 60‒65. |
| [107] |
Gong M, Zhou Z, Jin J, et al. (2020) Effects of soaking on physicochemical properties of four kinds of rice used in Huangjiu brewing. J Cereal Sci 91: 102855. https://doi.org/10.1016/j.jcs.2019.102855 doi: 10.1016/j.jcs.2019.102855
|
| [108] |
Bello-Perez LA, Flores-Silva PC, Agama-Aceved E, et al. (2020) Starch digestibility: past, present, and future. J Sci Food Agric 100: 5009‒5016. https://doi.org/10.1002/jsfa.8955 doi: 10.1002/jsfa.8955
|
| [109] |
Wongsagonsup R, Pujchakarn T, Jitrakbumrung S, et al. (2014) Effect of cross-linking on physicochemical properties of tapioca starch and its application in soup product. Carbohydr Polym 101: 656‒665. https://doi.org/10.1016/j.carbpol.2013.09.100 doi: 10.1016/j.carbpol.2013.09.100
|
| [110] |
Donmez D, Pinho L, Patel B, et al. (2021) Characterization of starch-water interactions and their effects on two key functional properties: Starch gelatinization and retrogradation. Curr Opin Food Sci 39: 103‒109. https://doi.org/10.1016/j.cofs.2020.12.018 doi: 10.1016/j.cofs.2020.12.018
|
| [111] |
Zhang J, Liu Y, Wang P, et al. (2025) The effect of protein-starch interaction on the structure and properties of starch, and its application in flour products. Foods 14: 778. https://doi.org/10.3390/foods14050778 doi: 10.3390/foods14050778
|
| [112] |
Zaidul ISM, Nik Norulaini NA, Mohd Omar AK, et al. (2007) RVA analysis of mixtures of wheat flour and potato, sweet potato, yam, and cassava starches. Carbohydr Polym 69: 784‒791. https://doi.org/10.1016/j.carbpol.2007.02.021 doi: 10.1016/j.carbpol.2007.02.021
|
| [113] |
Mpili P, Vicent V, Rweyemamu L (2024). Evaluation of the proximate composition, functional, and pasting properties of ichipipi maize flour. Appl Food Res 4: 100408. https://doi.org/10.1016/j.afres.2024.100408 doi: 10.1016/j.afres.2024.100408
|
| [114] |
Chhabra N, Kaur A, Kaur A (2018). Assessment of physicochemical characteristics and modifications of pasting properties of different varieties of maize flour using additives. J Food Sci Technol 55: 4111‒4118. https://doi.org/10.1007/s13197‒018‒3337‒1 doi: 10.1007/s13197‒018‒3337‒1
|
| [115] |
Polnaya FJ, Huwae AA, Tetelepta G (2018). Karakteristik sifat fisiko‒kimia dan fungsional pati sagu ihur (Metroxylon sylvestre) dimodifikasi dengan hidrolisis asam (Physicochemical and functional characteristics of Ihur sago starch (metroxylon sylvestre) modified through acid hydrolysis). Agritech 38: 7‒15. https://doi.org/10.22146/agritech.16611 doi: 10.22146/agritech.16611
|
| [116] |
Taghdir M, Mazloomi SM, Honar N, et al. (2017) Effect of soy flour on nutritional, physicochemical, and sensory characteristics of gluten‐free bread. Food Sci Nutr 5: 439‒445. https://doi.org/10.1002/fsn3.411 doi: 10.1002/fsn3.411
|
| [117] |
Julianti E, Rusmarilin H, Yusraini E (2017) Functional and rheological properties of composite flour from sweet potato, maize, soybean and xanthan gum. J Saudi Soc Agric Sci 16: 171‒177. https://doi.org/10.1016/j.jssas.2015.05.005 doi: 10.1016/j.jssas.2015.05.005
|
| [118] |
Okafor JN, Obiegbuna JE, Agu HO (2021) Functional and pasting properties of composite flour from wheat, sweet potato and soybean. Int J Environ Agric Res 12: 1‒9. https://doi.org/10.5281/ZENODO.5855102 doi: 10.5281/ZENODO.5855102
|
| [119] | Varghese S, Awana M, Mondal D, et al. (2022) Amylose-amylopectin ratio: Comprehensive understanding of structure, physicochemical attributes, and applications of starch. In: Thomas S, Ajitha AR, Chirayil CJ, et al. (Eds.), Handbook of Biopolymers, Singapore: Springer Nature Singapore, 1‒30. https://doi.org/10.1007/978‒981‒16‒6603‒2_48‒1 |
| [120] |
Elisabeth DAA, Utomo JS, Byju G, et al. (2022) Cassava flour production by small scale processors, its quality and economic feasibility. Food Sci Technol 42: e41522. https://doi.org/10.1590/fst.41522 doi: 10.1590/fst.41522
|
| [121] |
Verma AK, Pathak V, Singh VP (2014) Comparative cost assessment of refined wheat and soy flour based chicken meat noodles. Asian J Dairy Food Res 33: 123‒125. https://doi.org/10.5958/0976-0563.2014.00587.9 doi: 10.5958/0976-0563.2014.00587.9
|
| [122] |
Saputra HDD (2022) Uji kualitas french baguette dengan tepung kedelai sebagai substitusi tepung terigu: Quality test of french baguette with soybean flour as a wheat flour substitute. Jurnal Ilmiah Pariwisata dan Bisnis 1: 1936‒1954. https://doi.org/10.22334/paris.v1i8.132 doi: 10.22334/paris.v1i8.132
|
| [123] | Adityawati IS (2019) Formulasi Bubur Instan Untuk Pemenuhan Kebutuhan Asupan Nutrisi Ibu Menyusui Menggunakan Linear Programming (Instant porridge formulation to fulfill the nutritional intake needs of breastfeeding mothers using linear programming). Doctoral dissertation, Universitas Brawijaya. Available from: http://repository.ub.ac.id/id/eprint/181560 |
| [124] |
Arief RW, Asnawi R, Richana N (2015) Penganekaragaman pangan olahan jagung dan analisis kelayakannya secara ekonomi di Kecamatan Pekalongan Kabupaten Lampung Timur (Diversification of processed maize-based food products and economic feasibility analysis in Pekalongan District, East Lampung Regency, Indonesia). Prosiding Seminar Nasional Pengembangan Teknologi Pertanian, Politeknik Negeri Lampung 2015: 161‒169. https://doi.org/10.25181/prosemnas.v0i0.526 doi: 10.25181/prosemnas.v0i0.526
|
| [125] |
Kusuma PTWW, Mayasti NKI (2014) Analisa kelayakan finansial pengembangan usaha produksi komoditas lokal: mie berbasis jagung (Financial feasibility analysis of local commodity production business development: corn-based noodles). Agritech 34: 194‒202. https://doi.org/10.22146/agritech.9510 doi: 10.22146/agritech.9510
|
Figures(5) / Tables(8)
Sri Satya Antarlina, Joko Susilo Utomo, Erliana Ginting, Dian Adi Anggraeni Elisabeth, Aniswatul Khamidah, Indrie Ambarsari, Heni Purwaningsih, Siti Dewi Indrasari, Ulyatu Fitrotin, Alit Pangestu, Fitri Nur Kayati, Yessy Anna Pratiwi, Sugeng Pondang Sugiharto, Hozin Aziz. Physicochemical characteristics, pasting behaviors and production cost of pre-soaked soybean and corn flours from local and improved varieties for supporting local food utilization[J]. AIMS Agriculture and Food, 2026, 11(1): 40-71. doi: 10.3934/agrfood.2026003
DownLoad: