Dried fish (DF) are rich in protein and widely available worldwide; however, they have long been limited to being used as a traditional food. This study investigated the structural and functional properties of dried fish protein isolates (DFPIs) extracted from seven commonly consumed DF species in Bangladesh, including both sun-dried and fermented varieties. The isolates were prepared via isoelectric precipitation. Sodium dodecyl sulfate–polyacrylamide gel electrophoresis (SDS-PAGE) analysis revealed that the DFPIs lacked intact muscle protein bands and were primarily composed of peptides of < 70 kDa. Circular dichroism spectroscopy showed extensive protein unfolding and hydrolysis, with only the Ganges River sprat DFPI retaining some ordered tertiary structure. The drying and fermentation processes significantly disrupted the secondary structure, resulting in low α-helix content and high proportions of β-sheets and random coils. Consequently, protein yield during extraction was relatively low, with a maximum of 36%. At neutral pH (7.0), DFPIs exhibited low heat-induced coagulation (maximum 23%) but showed excellent oil-holding capacity (up to 20 g/g), likely due to exposed hydrophobic groups. They also demonstrated good gelation abilities (minimum gelling concentration of 3–7%) and emulsifying properties, with Bombay duck DFPI forming stable emulsions with droplet sizes as small as 2 µm. These findings highlight the potential of DFPIs as functional ingredients in heat-processed food formulations, particularly as heat-stable emulsifiers.
Citation: Huan Sun, Derek Stephen Johnson, Rotimi Emmanuel Aluko. Structural and functional properties of dried fish protein isolates[J]. AIMS Agriculture and Food, 2025, 10(3): 770-789. doi: 10.3934/agrfood.2025040
Dried fish (DF) are rich in protein and widely available worldwide; however, they have long been limited to being used as a traditional food. This study investigated the structural and functional properties of dried fish protein isolates (DFPIs) extracted from seven commonly consumed DF species in Bangladesh, including both sun-dried and fermented varieties. The isolates were prepared via isoelectric precipitation. Sodium dodecyl sulfate–polyacrylamide gel electrophoresis (SDS-PAGE) analysis revealed that the DFPIs lacked intact muscle protein bands and were primarily composed of peptides of < 70 kDa. Circular dichroism spectroscopy showed extensive protein unfolding and hydrolysis, with only the Ganges River sprat DFPI retaining some ordered tertiary structure. The drying and fermentation processes significantly disrupted the secondary structure, resulting in low α-helix content and high proportions of β-sheets and random coils. Consequently, protein yield during extraction was relatively low, with a maximum of 36%. At neutral pH (7.0), DFPIs exhibited low heat-induced coagulation (maximum 23%) but showed excellent oil-holding capacity (up to 20 g/g), likely due to exposed hydrophobic groups. They also demonstrated good gelation abilities (minimum gelling concentration of 3–7%) and emulsifying properties, with Bombay duck DFPI forming stable emulsions with droplet sizes as small as 2 µm. These findings highlight the potential of DFPIs as functional ingredients in heat-processed food formulations, particularly as heat-stable emulsifiers.
| [1] |
Gehring CK, Gigliotti JC, Moritz JS, et al. (2011) Functional and nutritional characteristics of proteins and lipids recovered by isoelectric processing of fish by-products and low-value fish: A review. Food Chem 124: 422–431. https://doi.org/10.1016/j.foodchem.2010.06.078 doi: 10.1016/j.foodchem.2010.06.078
|
| [2] |
Shaviklo AR (2015) Development of fish protein powder as an ingredient for food applications: A review. J Food Sci Technol 52: 648–661. https://doi.org/10.1007/s13197-013-1042-7 doi: 10.1007/s13197-013-1042-7
|
| [3] |
Chung Y-C, Ho M-L, Chyan F-L, et al. (2000) Utilization of freeze-dried mackerel (Scomber australasicus) muscle proteins as a binder in restructured meat. Fish Sci 66: 130–135. https://doi.org/10.1046/j.1444-2906.2000.00019.x doi: 10.1046/j.1444-2906.2000.00019.x
|
| [4] |
Ramírez JA, Díaz-Sobac R, Morales OG, et al. (1999) Evaluation of freeze-dried surimi from tilapia and fat sleeper as emulsifiers. Ciencia y Tecnologia Alimentaria 2: 210–214. https://doi.org/10.1080/11358129909487604 doi: 10.1080/11358129909487604
|
| [5] |
Shaviklo GR, Olafsdottir A, Sveinsdottir K, et al. (2011) Quality characteristics and consumer acceptance of a high fish protein puffed corn-fish snack. J Food Sci Technol 48: 668–676. https://doi.org/10.1007/s13197-010-0191-1 doi: 10.1007/s13197-010-0191-1
|
| [6] |
Shaviklo GR, Thorkelsson G, Sveinsdottir K, et al. (2011) Chemical properties and sensory quality of ice cream fortified with fish protein. J Sci Food Agric 91: 1199–1204. https://doi.org/10.1002/jsfa.4299 doi: 10.1002/jsfa.4299
|
| [7] |
Adeleke RO, Odedeji JO (2010) Acceptability studies on bread fortified with tilapia fish flour. Pak J Nutr 9: 531–534. https://doi.org/10.3923/pjn.2010.531.534 doi: 10.3923/pjn.2010.531.534
|
| [8] | Ibrahim SM (2009) Evaluation of production and quality of salt-biscuits supplemented with fish protein concentrate. World J Dairy Food Sci 4: 28–31. |
| [9] |
Sathivel S, Bechtel PJ, Babbitt JK, et al. (2005) Functional, nutritional, and rheological properties of protein powders from arrowtooth flounder and their application in mayonnaise. J Food Sci 70: E57–E63. https://doi.org/10.1111/j.1365-2621.2005.tb07091.x doi: 10.1111/j.1365-2621.2005.tb07091.x
|
| [10] |
Rahman MA, Saifullah M, Islam MN (2012) Fish powder in instant fish soup mix. J Bangladesh Agric Univ 10: 145–148. https://doi.org/10.3329/jbau.v10i1.12106 doi: 10.3329/jbau.v10i1.12106
|
| [11] | Shaviklo RA (2012) Developing value-added products from lantern fish. Infofish Int 2: 42–46. |
| [12] |
Shaviklo GR, Thorkelsson G, Sveinsdottir K, et al. (2013) Studies on processing, consumer survey and storage stability of a ready-to-reconstitute fish cutlet mix. J Food Sci Technol 50: 900–908. https://doi.org/10.1007/s13197-011-0417-x doi: 10.1007/s13197-011-0417-x
|
| [13] |
Surasani VKR, Raju C, Sofi FR, et al. (2022) Utilization of protein isolates from rohu (labeo rohita) processing waste through incorporation into fish sausages; quality evaluation of the resultant paste and end product. J Sci Food Agric 102: 1263–1270. https://doi.org/10.1002/jsfa.11464 doi: 10.1002/jsfa.11464
|
| [14] | Hussain I, Akhtar N, Hussain S (2007) Evaluation of weaning food khitchri incorporated with different levels of fish protein concentrate. Anim Plant Sci 17: 12–17. |
| [15] |
Shaviklo AR, Etemadian Y (2019) Overcoming current challenges in commercial applications of fish protein isolates in food and feed systems: A review. J Food Sci Technol 56: 4775–4784. https://doi.org/10.1007/s13197-019-03966-5 doi: 10.1007/s13197-019-03966-5
|
| [16] |
Pires C, Costa S, Batista AP, et al. (2012) Properties of protein powder prepared from cape hake by-products. J Food Eng 108: 268–275. https://doi.org/10.1016/j.jfoodeng.2011.08.020 doi: 10.1016/j.jfoodeng.2011.08.020
|
| [17] |
Ochiai Y, Ozawa H (2020) Biochemical and physicochemical characteristics of the major muscle proteins from fish and shellfish. Fish Sci 86: 729–740. https://doi.org/10.1007/s12562-020-01444-y doi: 10.1007/s12562-020-01444-y
|
| [18] |
Hashimoto K, Watabe S, KoNo M, et al. (1979) Muscle protein composition of sardine and mackerel. Bull Jpn Soc Sci Fish 45: 1435–1441. https://doi.org/10.2331/suisan.45.1435 doi: 10.2331/suisan.45.1435
|
| [19] |
Feng X, Yu X, Yang Y, et al. (2023) Improving the freeze-thaw stability of fish myofibrils and myofibrillar protein gels: current methods and future perspectives. Food Hydrocoll 144: 109041. https://doi.org/10.1016/j.foodhyd.2023.109041 doi: 10.1016/j.foodhyd.2023.109041
|
| [20] |
Xiong Y, Li Q, Miao S, et al. (2019) Effect of ultrasound on physicochemical properties of emulsion stabilized by fish myofibrillar protein and xanthan gum. Innovative Food Sci Emerg Technol 54: 225–234. https://doi.org/10.1016/j.ifset.2019.04.013 doi: 10.1016/j.ifset.2019.04.013
|
| [21] |
Ding J, Zhao X, Li X, et al. (2022) Effects of different recovered sarcoplasmic proteins on the gel performance, water distribution and network structure of silver carp surimi. Food Hydrocoll 131: 107835. https://doi.org/10.1016/j.foodhyd.2022.107835 doi: 10.1016/j.foodhyd.2022.107835
|
| [22] |
Belton B, Johnson DS, Thrift E, et al. (2022) Dried fish at the intersection of food science, economy, and culture: A global survey. Fish Fish 23: 941–962. https://doi.org/10.1111/faf.12664 doi: 10.1111/faf.12664
|
| [23] |
Banna MdH Al, Al Zaber A, Rahman N, et al. (2022) Nutritional value of dry fish in Bangladesh and its potential contribution to addressing malnutrition: a narrative review. Fishes 7: 240. https://doi.org/10.3390/fishes7050240 doi: 10.3390/fishes7050240
|
| [24] |
Bhowmik S, Zakaria MA, Sarwar MdS, et al. (2022) Development and nutritional index of ready to use fish products (rufps) from small fish species: Future superfoods for consumers. Appl Food Res 2: 100111. https://doi.org/10.1016/j.afres.2022.100111 doi: 10.1016/j.afres.2022.100111
|
| [25] |
Hamdani, Rizal TA, Muhammad Z (2018) Fabrication and testing of hybrid solar-biomass dryer for drying fish. Case Stud Thermal Eng 12: 489–496. https://doi.org/10.1016/j.csite.2018.06.008 doi: 10.1016/j.csite.2018.06.008
|
| [26] |
Nagwekar N, Tidke V, Thorat BN (2017) Microbial and biochemical analysis of dried fish and comparative study using different drying methods. Drying Technol 35: 1481–1491. https://doi.org/10.1080/07373937.2016.1256889 doi: 10.1080/07373937.2016.1256889
|
| [27] | Akande G, Diei-Ouadi Y (2010) Post-harvest losses in small-scale fisheries: case studies in five sub-saharan african countries, In: FAO (Ed.), FAO Fisheries and Aquaculture Technical Paper, Rome, FAO, 15–34. |
| [28] |
Kruijssen F, Tedesco I, Ward A, et al. (2020) Loss and waste in fish value chains: a review of the evidence from low and middle-income countries. Glob Food Sec 26: 100434. https://doi.org/10.1016/j.gfs.2020.100434 doi: 10.1016/j.gfs.2020.100434
|
| [29] |
Shamsuzzaman MdM, Hoque Mozumder MM, Mitu SJ, et al. (2020) The economic contribution of fish and fish trade in Bangladesh. Aquac Fish 5: 174–181. https://doi.org/10.1016/j.aaf.2020.01.001 doi: 10.1016/j.aaf.2020.01.001
|
| [30] |
Rasul G, Yuan C, Azad Shah AKM (2021) Chemical composition and nutritional value of dried fish in Bangladesh. Egypt J Aquat Biol Fish 25: 379–399. https://doi.org/10.21608/ejabf.2021.189666 doi: 10.21608/ejabf.2021.189666
|
| [31] |
Sun H, Johnson DS, Aluko RE (2025) Nutrient and heavy metals composition of dried fish varieties from Bangladesh. LWT 215: 117233. https://doi.org/10.1016/j.lwt.2024.117233 doi: 10.1016/j.lwt.2024.117233
|
| [32] |
Osemwota EC, Alashi AM, Aluko RE (2021) Comparative study of the structural and functional properties of membrane-isolated and isoelectric ph precipitated green lentil seed protein isolates. Membranes 11: 694. https://doi.org/10.3390/membranes11090694 doi: 10.3390/membranes11090694
|
| [33] |
Markwell MAK, Haas SM, Bieber LL, et al. (1978) A modification of the lowry procedure to simplify protein determination in membrane and lipoprotein samples. Anal Biochem 87: 206–210. https://doi.org/10.1016/0003-2697(78)90586-9 doi: 10.1016/0003-2697(78)90586-9
|
| [34] |
Haskard CA, Li-Chan ECY (1998) Hydrophobicity of bovine serum albumin and ovalbumin determined using uncharged (PRODAN) and anionic (ANS) fluorescent probes. J Agric Food Chem 46: 2671–2677. https://doi.org/10.1021/jf970876y doi: 10.1021/jf970876y
|
| [35] |
Whitmore L, Wallace BA (2004) DICHROWEB, An online server for protein secondary structure analyses from circular dichroism spectroscopic data. Nucleic Acids Res 32: W668–W673. https://doi.org/10.1093/nar/gkh371 doi: 10.1093/nar/gkh371
|
| [36] |
Laemmli UK (1970) Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature 227: 680–685. https://doi.org/10.1038/227680a0 doi: 10.1038/227680a0
|
| [37] |
Raikos V, Neacsu M, Russell W, et al. (2014) Comparative study of the functional properties of lupin, green pea, fava bean, hemp, and buckwheat flours as affected by pH. Food Sci Nutr 2: 802–810. https://doi.org/10.1002/fsn3.143 doi: 10.1002/fsn3.143
|
| [38] |
Malomo SA, He R, Aluko RE (2014) Structural and functional properties of hemp seed protein products. J Food Sci 79: C1512–C521. https://doi.org/10.1111/1750-3841.12537 doi: 10.1111/1750-3841.12537
|
| [39] |
Chao D, Jung S, Aluko RE (2018) Physicochemical and functional properties of high pressure-treated isolated pea protein. Innovative Food Sci Emerg Technol 45: 179–185. https://doi.org/10.1016/j.ifset.2017.10.014 doi: 10.1016/j.ifset.2017.10.014
|
| [40] |
Chen YC, Jaczynski J (2007) Protein recovery from rainbow trout (Oncorhynchus mykiss) processing byproducts via isoelectric solubilization/precipitation and its gelation properties as affected by functional additives. J Agric Food Chem 55: 9079–9088. https://doi.org/10.1021/jf071992w doi: 10.1021/jf071992w
|
| [41] |
Zhong S, Liu S, Cao J, et al. (2016) Fish protein isolates recovered from silver carp (Hypophthalmichthys molitrix) by-products using alkaline pH solubilization and precipitation. J Aquatic Food Prod Technol 25: 400–413. https://doi.org/10.1080/10498850.2013.865282 doi: 10.1080/10498850.2013.865282
|
| [42] |
Tadpitchayangkoon P, Park JW, Yongsawatdigul J (2010) conformational changes and dynamic rheological properties of fish sarcoplasmic proteins treated at various pHs. Food Chem 121: 1046–1052. https://doi.org/10.1016/j.foodchem.2010.01.046 doi: 10.1016/j.foodchem.2010.01.046
|
| [43] |
Kobayashi Y, Park JW (2018) Optimal blending of differently refined fish proteins based on their functional properties. J Food Process Preserv 42: e13346. https://doi.org/10.1111/jfpp.13346 doi: 10.1111/jfpp.13346
|
| [44] | Mohd Khairi INB, Huda N, Wan Abdullah WN, et al. (2014) Protein quality of fish fermented product: budu and rusip. Asia Pacific J Sust Agric Food Energy 2: 17–22. |
| [45] |
Wang PA, Vang B, Pedersen AM, et al. (2011) Post-mortem degradation of myosin heavy chain in intact fish muscle: effects of ph and enzyme inhibitors. Food Chem 124: 1090–1095. https://doi.org/10.1016/j.foodchem.2010.07.093 doi: 10.1016/j.foodchem.2010.07.093
|
| [46] |
Wang R, Chen C, Guo S (2017) Effects of drying methods on starch crystallinity of gelatinized foxtail millet (α-millet) and its eating quality. J Food Eng 207: 81–89. https://doi.org/10.1016/j.jfoodeng.2017.03.018 doi: 10.1016/j.jfoodeng.2017.03.018
|
| [47] |
Poljanec I, Marušić Radovčić N, Petričević S, et al. (2021) Proteolysis and protein oxidation throughout the smoked dry-cured ham process. Food Chem 362: 130207. https://doi.org/10.1016/j.foodchem.2021.130207 doi: 10.1016/j.foodchem.2021.130207
|
| [48] |
Sun LC, Lin YC, Liu WF, et al. (2019) Effect of pH shifting on conformation and gelation properties of myosin from skeletal muscle of blue round scads (Decapterus maruadsi). Food Hydrocoll 93: 137–145. https://doi.org/10.1016/j.foodhyd.2019.02.026 doi: 10.1016/j.foodhyd.2019.02.026
|
| [49] |
Tan L, Hong P, Yang P, et al. (2019) Correlation between the water solubility and secondary structure of tilapia-soybean protein co-precipitates. Molecules 24: 4337. https://doi.org/10.3390/molecules24234337 doi: 10.3390/molecules24234337
|
| [50] |
Liu R, Zhao S, Liu Y, et al. (2010) Effect of pH on the gel properties and secondary structure of fish myosin. Food Chem 121: 196–202. https://doi.org/10.1016/j.foodchem.2009.12.030 doi: 10.1016/j.foodchem.2009.12.030
|
| [51] |
Kelly SM, Jess TJ, Price NC (2005) How to study proteins by circular dichroism. Biochim Biophys Acta (BBA)-Proteins and Proteomics 1751: 119–139. https://doi.org/10.1016/j.bbapap.2005.06.005 doi: 10.1016/j.bbapap.2005.06.005
|
| [52] |
Aluko RE, Yada RY (1997) Some physicochemical and functional properties of cowpea (vigna unguiculata) isoelectric protein isolate as a function of pH and salt concentration. Int J Food Sci Nutr 48: 31–39. https://doi.org/10.3109/09637489709006961 doi: 10.3109/09637489709006961
|
| [53] |
Álvarez C, Lélu P, Lynch SA, et al. (2018) Optimised protein recovery from mackerel whole fish by using sequential acid/alkaline isoelectric solubilization precipitation (ISP) extraction assisted by ultrasound. LWT 88: 210–216. https://doi.org/10.1016/j.lwt.2017.09.045 doi: 10.1016/j.lwt.2017.09.045
|
| [54] |
Tan Y, Chang SK (2021) Protein extraction pH and cross‐linking affect physicochemical and textural properties of protein gels made from channel catfish by‐products. J Sci Food Agric 101: 4799–4807. https://doi.org/10.1002/jsfa.11126 doi: 10.1002/jsfa.11126
|
| [55] |
Rodrigues Freitas I, Cortez-Vega WR, Prentice C (2016) Physicochemical and functional properties of protein recovered from fish waste. J Aquatic Food Prod Technol 25: 1034–1044. https://doi.org/10.1080/10498850.2015.1008714 doi: 10.1080/10498850.2015.1008714
|
| [56] |
Hidalgo J, Gamper E (1977) Solubility and heat stability of whey protein concentrates. J Dairy Sci 60: 1515–1518. https://doi.org/10.3168/jds.S0022-0302(77)84061-7 doi: 10.3168/jds.S0022-0302(77)84061-7
|
| [57] |
Nasabi M, Labbafi M, Mousavi ME, et al. (2017) Effect of salts and nonionic surfactants on thermal characteristics of egg white proteins. Int J Biol Macromol 102: 970–976. https://doi.org/10.1016/j.ijbiomac.2017.04.102 doi: 10.1016/j.ijbiomac.2017.04.102
|
| [58] |
Deng Y, Rosenvold K, Karlsson AH, et al. (2002) Relationship between thermal denaturation of porcine muscle proteins and water‐holding capacity. J Food Sci 67: 1642–1647. https://doi.org/10.1111/j.1365-2621.2002.tb08698.x doi: 10.1111/j.1365-2621.2002.tb08698.x
|
| [59] |
Kumarakuru K, Reddy CK, Haripriya S (2018) Physicochemical, morphological and functional properties of protein isolates obtained from four fish species. J Food Sci Technol 55: 4928–4936. https://doi.org/10.1007/s13197-018-3427-0 doi: 10.1007/s13197-018-3427-0
|
| [60] |
Wasswa J, Tang J, Gu X (2008) Functional properties of grass carp (Ctenopharyngodon idella), nile perch (Lates niloticus) and nile tilapia (Oreochromis niloticus) skin hydrolysates. Int J Food Prop 11: 339–350. https://doi.org/10.1080/10942910701381188 doi: 10.1080/10942910701381188
|
| [61] |
Ma KK, Grossmann L, Nolden AA, et al. (2022) Functional and physical properties of commercial pulse proteins compared to soy derived protein. Future Foods 6: 100155. https://doi.org/10.1016/j.fufo.2022.100155 doi: 10.1016/j.fufo.2022.100155
|
| [62] |
Shaviklo GR, Thorkelsson G, Arason S, et al. (2012) Characteristics of freeze-dried fish protein isolated from saithe (Pollachius virens). J Food Sci Technol 49: 309–318. https://doi.org/10.1007/s13197-011-0285-4 doi: 10.1007/s13197-011-0285-4
|
| [63] |
García-Moreno PJ, Guadix A, Guadix EM, et al. (2016) Physical and oxidative stability of fish oil-in-water emulsions stabilized with fish protein hydrolysates. Food Chem 203: 124–135. https://doi.org/10.1016/j.foodchem.2016.02.073 doi: 10.1016/j.foodchem.2016.02.073
|
| [64] |
Rajasekaran B, Singh A, Zhang B, et al. (2022) Changes in emulsifying and physical properties of shrimp oil/soybean oil‐in‐water emulsion stabilized by fish myofibrillar protein during the storage. Eur J Lipid Sci Technol 124: 2200068. https://doi.org/10.1002/ejlt.202200068 doi: 10.1002/ejlt.202200068
|
Figures(4) / Tables(3)
Huan Sun, Derek Stephen Johnson, Rotimi Emmanuel Aluko. Structural and functional properties of dried fish protein isolates[J]. AIMS Agriculture and Food, 2025, 10(3): 770-789. doi: 10.3934/agrfood.2025040
DownLoad: