Export file:

Format

  • RIS(for EndNote,Reference Manager,ProCite)
  • BibTex
  • Text

Content

  • Citation Only
  • Citation and Abstract

Preparation of LiMn2O4 Graphene Hybrid Nanostructure by Combustion Synthesis and Their Electrochemical Properties

1 Department of Nanotechnology, Center for Post Graduate Studies, Bengaluru Region, VIAT, Muddenahalli, Chikkaballapur-562101 Visvesvaraya Technological University (VTU), Karnataka;
2 International Advanced Research Centre for Powdered Metallurgy and New Materials (ARCI), Balapur, Hyderabad-500005, India

Special Issues: Multifunctional Oxide Materials

The LiMn2O4 graphene hybrid cathode material has been synthesized by spray drying combustion process. The spinel structure cubic phase LiMn2O4 graphene hybrid material was prepared by spray drying process at 120 ℃ and subsequent heat treatment at 700 ℃ for 1 hour. The result indicates that the spinel shaped LiMn2O4 particles wrapped with graphene sheets were formed with particle size in the range of 60-70 nm. The charge-discharge measurement indicates that the LiMn2O4 graphene hybrid material shows an improved discharge capacity of 139 mAh/g at 0.1C rate. The pristine LiMn2O4 nano crystals present only about 132 mAh/g discharge capacity. The LiMn2O4 graphene hybrid samples show good cyclic performance with only 13% of capacity fading in 30 cycles when compared to the pristine LiMn2O4 that shows 22% of capacity fading in 30 cycles. The capacity retention of the LiMn2O4 graphene hybrid samples is about 10% higher than the pristine cycle after 30 cycles.
  Figure/Table
  Supplementary
  Article Metrics

Keywords Li ion battery; combustion method; LiMn2O4; reduced graphene

Citation: Dinesh Rangappa, Erabhoina Hari Mohan, Varma Siddhartha, Raghavan Gopalan, Tata Narasinga Rao. Preparation of LiMn2O4 Graphene Hybrid Nanostructure by Combustion Synthesis and Their Electrochemical Properties. AIMS Materials Science, 2014, 1(4): 174-183. doi: 10.3934/matersci.2014.4.174

References

  • 1. Maclean LAH, Poinsignon C, Amarilla JA, et al. (1995) Electrochemical behaviour of natural and synthetic ramsdellite. J Mater Chem 5: 1183-1189.    
  • 2. Xia Y, Zhou Y, Yoshio M (1997) Capacity Fading on Cycling of 4 V Li/LiMn2O4 Cells. J Electrochem Soc 144: 2593-2600.    
  • 3. Tsai YW, Santhanam R, Hwang BJ, et al. (2003) Structure stabilization of LiMn2O4 cathode material by bimetal dopants. J Power Sources 119: 701.
  • 4. Jeong WT, Joo JH, Lee KS (2003) Improvement of electrode performances of spinel LiMn2O4 prepared by mechanical alloying and subsequent firing. J Power Sour 119: 690-694.
  • 5. Schalkwijk V, Scrosati WA, Eds B (2002) Advances in Lithium-ion Batteries, Kluwer Academic/Plenum Publishers, New York.
  • 6. Wang XL, Feygenson M, Aronson MC, et al. (2010) Sn/SnOx core-shell nanospheres: Synthesis, anode performance in Li-Ion batteries, and superconductivity. J Phys Chem C114: 14697-14703.
  • 7. Thackeray MM, Shao- Horn Y, Kahaian AJ, et al. (1998) Structural Fatigue in Spinel Electrodes in High Voltage (4 V) Li/LixMnzO4 Cells. Electrochem Solid State lett 1: 7.
  • 8. Saitoh M, Yoshida S, Yamane H, et al. (2003) Capacity Fading of the Acid-treated Lithium Manganese Oxides in High-temperature Storage. J Power Sources 122: 162-168.    
  • 9. Shin Y, Manthiram A (2002) Microstrain and Capacity Fade in Spinel. Manganese Oxides. Electrochem Solid State Lett 5: A55-A58.    
  • 10. Taniguchi I (2005) Powder properties of partially substituted LiMxMn2-xO4 (M = Al, Cr, Fe and Co) synthesized by ultrasonic spray pyrolysis. Mater Chem Phys 92: 172-179.    
  • 11. Jeong IS, Kim JU, Gu HB (2001) Electrochemical properties of LiMgyMn2-yO4 spinel phases for rechargeable lithium batteries. J Power Sources 102: 55-59.    
  • 12. Yi TF, Zhu YR, Zhu XD (2009) A review of recent developments in the surface modification of LiMn2O4 as cathode material of power lithium-ion battery. Ionics 15: 779-784.    
  • 13. Amarilla JM, Petrov K, Pico F, et al. (2009) Sucrose-aided combus-tion synthesis of nanosized LiMn1.99·yLiyM0.01O4 (M = Al3+, Ni2+, Cr3+, Co3+, y = 0.01 and 0.06) spinels. J Power Sources 191: 591-600.
  • 14. Chan HW, Duh JG, Sheen SR (2003) LiMn2O4 cathode doped with excess lithium and synthesized by co-precipitation for Li-ion batteries. J Power Sources 115: 110-118.    
  • 15. Choi HJ, Lee KM, Kim GH (2001) Mechanochemical synthesis and electrochemical properties of LiMn2O4. J Am Ceram Soc 84: 242-244.    
  • 16. Sun YK, Oh IH, Kim KY (1997) Synthesis of Spinel LiMn2O4 by the Sol-Gel Method for a Cathode-Active Material in Lithium Secondary. Ind Eng Chem Res 36: 4839-4846.    
  • 17. Yan H, Hnang X, Chen L (1999) J Power Source 81: 647-650.
  • 18. Ohano K, Saitou M (2003) Techinical Report.
  • 19. Du K, Zhang H (2003) Preparation and performance of spinel LiMn2O4 by a citrate route with combustion. J Alloy Compd 352: 250-254.    
  • 20. Fey GTK, Cho YD, Kumar TP (2006) Mater. Chem. Phys. 99: 451-415.
  • 21. Park HB, Kim J, Lee CW (2001) Synthesis of LiMn2O4 powder by auto-ignited combustion of poly(acrylic acid)-metal nitrate precursor. J Power Sources 92: 124-130.    
  • 22. Liu XM, Huang ZD, Oh S, et al. (2010) Sol-gel synthesis of multiwalled carbon nanotube- LiMn2O4 nanocomposites as cathode materials for Li-ion batteries. J Power Sources 195: 4290-4296.    
  • 23. Paek SM, Yoo E (2009) I. Honma, Nano Lett, 9: 72-76.    
  • 24. Bak SM, Nam KW, Lee CW, et al. (2011) Spinel LiMn2O4/reduced graphene oxide hybrid for high rate lithium ion batteries. J Mater Chem 21: 17309-17315.    
  • 25. Jain SR, Adiga KC, Verneker VR (1981) A New Approach to Thermochemical Calculations of Condensed Fuel-Oxidizer Mixtures. Comb Flam 40: 71-79.    
  • 26. Hummers WS, Offeman RE (1958) Preparation of Graphitic Oxide. J Am Chem Soc 80: 1339.    
  • 27. Hon YM, Lin SP, Fung KZ, et al. (2002) Synthesis and characterization of nano-LiMn2O4 powder by tartaricacid gel process. J Euro Ceram Soc 22: 653-660.    
  • 28. Spakr ME, Novak P, Schnyder B et al. (1998) J Electrochem Soc 145: 1113.
  • 29. Thackeray MM, David WIF, Bruce PG (1983) Lithium Insertion Into Manganese Spinels. Mater Res Bull 18: 461-472.    
  • 30. Ramana CV, Massot M, Julien CM (2005) XPS and Raman spectroscopic characterization of LiMn2O4 spinels. Surf Interface Anal 37: 412-416.    
  • 31. Ma PC, Kim JK, Tang BZ (2006) Functionalization of carbon nanotubes using a silane coupling agent. Carbon 44: 3232-3238.    
  • 32. Geng Y, Wang SJ, Kim JK (2009) Preparation of graphite nanoplatelets and graphene sheets. J Colloids Interface Sci 336: 592-598.    
  • 33. Veluchamy A, Ikuta H, Wakihara M (2001) Boron-substituted manganese spinel oxide cathode for lithium ion battery. Solid State Ionis 143: 161-171.    
  • 34. Sinha NN, Munichandraiah N (2009) The effect of particle size on performance of cathodematerials of Li-ion batteries. J Library IISc Ernet 89: 381-392.
  • 35. Wagemaker M, Kearley GJ, Van-Well AA, et al. (2003) Multiple Li positions inside oxygen octahedra in lithiated. TiO2 anatase. J Am Chem Soc 125: 840-848.    

 

This article has been cited by

  • 1. Mahesh Shastri, Vinay Gangaraju, M. Navya Rani, E. Harimohan, T.N. Rao, Dinesh Rangappa, Spray drying assisted Combustion synthesis of LiNi 0.45 Mn 1.45 Co 0.1 O 4 /Graphene nanocomposite and its electrochemical properties, Materials Today: Proceedings, 2017, 4, 11, 12223, 10.1016/j.matpr.2017.09.153
  • 2. Samira Naghdi, Mohaddeseh Sajjadi, Mahmoud Nasrollahzadeh, Kyong Yop Rhee, S. Mohammad Sajadi, Babak Jaleh, Cuscuta reflexa leaf extract mediated green synthesis of the Cu nanoparticles on graphene oxide/manganese dioxide nanocomposite and its catalytic activity toward reduction of nitroarenes and organic dyes, Journal of the Taiwan Institute of Chemical Engineers, 2018, 10.1016/j.jtice.2017.12.017

Reader Comments

your name: *   your email: *  

Copyright Info: 2014, Dinesh Rangappa, et al., licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution Licese (http://creativecommons.org/licenses/by/4.0)

Download full text in PDF

Export Citation

Copyright © AIMS Press All Rights Reserved