Export file:

Format

  • RIS(for EndNote,Reference Manager,ProCite)
  • BibTex
  • Text

Content

  • Citation Only
  • Citation and Abstract

Properties of chicken manure pyrolysis bio-oil blended with diesel and its combustion characteristics in RCEM, Rapid Compression and Expansion Machine

Yoshikawa Lab, Department of Environmental Science and Technology, Tokyo Institute of Technology, Kanagawa, Japan

Special Issues: Bio-blended Fuels

Bio-oil (bio-oil) was produced from chicken manure in a pilot-scale pyrolysis facility. The raw bio-oil had a very high viscosity and sediments which made direct application to diesel engines difficult. The bio-oil was blended with diesel fuel with 25% and 75% volumetric ratio at the normal temperature, named as blend 25. A rapid compression and expansion machine was used for a combustion test under the experimental condition corresponding to the medium operation point of a light duty diesel engine using diesel fuel, and blend 25 for comparison. The injection related pressure signal and cylinder pressure signal were instantaneously picked up to analyze the combustion characteristics in addition to the measurement of NOx and smoke emissions. Blend 25 resulted in reduction of the smoke emission by 80% and improvements of the apparent combustion efficiency while the NOx emission increased by 40%. A discussion was done based on the analysis results of combustion.
  Figure/Table
  Supplementary
  Article Metrics

Keywords Chicken manure; Pyrolysis; Blend fuel; RCEM; Heat Release; Exhaust gas emission

Citation: Sunbong Lee, Shaku Tei, Kunio Yoshikawa. Properties of chicken manure pyrolysis bio-oil blended with diesel and its combustion characteristics in RCEM, Rapid Compression and Expansion Machine. AIMS Energy, 2014, 2(3): 210-218. doi: 10.3934/energy.2014.3.210

References

  • 1. Charles JM (2013) The Feasibility of Using Raw Liquids from Fast Pyrolysis of Woody Biomass as Fuels for Compression-Ignition Engines: A Literature Review. SAE Int J Fuels Lubr 6: 251-262.    
  • 2. Solantausta Y, Nylund NO, Westerholm M, et al. (1993) Wood-Pyrolysis Oil as Fuel in a Direct-Power Plant. Bioresour Technol 46:177-188.    
  • 3. Chaiaramonti D, Bonini A, Fratini E, et al. (2003) Development of Emulsions from Biomass Pyrolysis Liquid and Diesel and Their Use in Engines―-Part2: Test in Diesel Engines. Biomass Bio energ 25:101-111.    
  • 4. Devan PK, Mahalakshii NV (2008) An Experimental Investigation on Performance and Emission Characteristics of Eucalyptus Oil-Diesel Blends in a D.I. Diesel Engine. SAE Paper 2008-01-0757.
  • 5. Herchel CM, Seiichi S, Yutaka M (2001) Operation and Combustion Characteristics of a DI Diesel Engine Fueled with Biomass Oil-Diesel Fuel Blends. SAE Paper 2001-28-0030.
  • 6. Carlos MM, Morris S (2011) Production of a refined biooil derived by fast pyrolysis of chicken manure with chemical and physical characteristics close to those of fossil fuels. J Env Sci Hea Part B 46: 630-637.    
  • 7. Augustinova J, Cvengrosova Z, Mikulec J, et al. (2013) Upgrading of biooil from fast pyrolysis. 46th International Conference on Petroleum Processing, June 7, Bratislava, Slovak Republic.
  • 8. Xu YF, Hu XG, Li WD, et al. (2011) Preparation and Characterization of Bio-oil from Biomass, In: Dr. Shahid Shaukat Editor, Progress in Biomass and Bioenergy Production, In Tech. Available from: http://www.intechopen.com/books/progress-in-biomass-and-bioenergy-production/preparation-and-characterization-of-bio-oil-from-biomass
  • 9. Schnizer MI, Monreal CM, Facey GA, et al. (2007) The Conversion of Chicken Manure to Biooil by Fast Pyrolysis I. Analysis of Biooils by FTIR and NMR Spectroscopy. J Env Sci Hea Part B 42: 71-77.
  • 10. Shigeharu K, Takeyuki K (1995) Development of a Rapid Compression-Expansion Machine Simulating Diesel Combustion. SAE Paper 952514.
  • 11. Hidenori K, Kentaro N, Tetsuya A (2007) A Study of Effect of Heterogeneity of Oxygen Concentration of Mixture in a Combustion Chamber on Combustion and Emissions of Diesel Engine. SAE Tech Paper 2007-01-1845.
  • 12. Heywood JB (1988) Internal Combustion Engine Fundamental. McGraw-Hill, NY: 505-506.
  • 13. Jurgen K, Gerhard K, Axel M, et al. (2008) Comparison of exhaust emissions and their mutagenicity from the combustion of biodiesel, vegetable oil, gas-to-liquid and petrodiesel fuels. Fuel 88: 1064-1069.
  • 14. Andreas J, Martin M, Stefan P, et al. (2009) Tailor-Made Fuels: The Potential of Oxygen Content in Fuels for Advanced Diesel Combustion Systems. SAE Tech Paper 2009-01-2765.

 

Reader Comments

your name: *   your email: *  

Copyright Info: 2014, Sunbong Lee, et al., licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution Licese (http://creativecommons.org/licenses/by/4.0)

Download full text in PDF

Export Citation

Copyright © AIMS Press All Rights Reserved