Research article Special Issues

Residue Derived Fuels as an Alternative Fuel for the Hellenic Power Generation Sector and their Potential for Emissions ReductionConstantinos S. Psomopoulos

  • Received: 01 July 2014 Accepted: 25 August 2014 Published: 02 September 2014
  • The European Union Landfill Directive (1999/31 EC) promotes more environmental friendly waste management options, by reducing the amount of wastes and more specific of biodegradable wastes, disposed of in landfills. The EU member states are adopting the mechanical-biological treatment process for municipal solid waste and non-hazardous industrial wastes to comply with the abovementioned Directive's targets on landfill diversion, and produce waste derived fuels such as refuse derived fuel and solid recovered fuel. Waste derived fuels present high calorific values depending on their synthesis and are being used both in dedicated waste-to-energy plants and as fuel substitutes in industrial processes. In this paper the refuse derived fuel and solid recovered fuel production and utilisation options in European Union are presented, and the possibilities in Greece based on the waste production and National Plan for Waste Management of the Ministry of Environment is attempted. The existing and ongoing studies on co-combustion and co-gasification with brown coal support the use of refuse derived fuel and solid recovered fuel as fuel on Hellenic Power Sector, adopting in the existing lignite power plants adequate Air Pollution Control systems. If the co-combustion or co-gasification of these alternative fuels is adopted from the Hellenic Power Sector a reduction on emissions is expected that cannot be neglected.

    Citation: Constantinos S. Psomopoulos. Residue Derived Fuels as an Alternative Fuel for the Hellenic Power Generation Sector and their Potential for Emissions ReductionConstantinos S. Psomopoulos[J]. AIMS Energy, 2014, 2(3): 321-341. doi: 10.3934/energy.2014.3.321

    Related Papers:

  • The European Union Landfill Directive (1999/31 EC) promotes more environmental friendly waste management options, by reducing the amount of wastes and more specific of biodegradable wastes, disposed of in landfills. The EU member states are adopting the mechanical-biological treatment process for municipal solid waste and non-hazardous industrial wastes to comply with the abovementioned Directive's targets on landfill diversion, and produce waste derived fuels such as refuse derived fuel and solid recovered fuel. Waste derived fuels present high calorific values depending on their synthesis and are being used both in dedicated waste-to-energy plants and as fuel substitutes in industrial processes. In this paper the refuse derived fuel and solid recovered fuel production and utilisation options in European Union are presented, and the possibilities in Greece based on the waste production and National Plan for Waste Management of the Ministry of Environment is attempted. The existing and ongoing studies on co-combustion and co-gasification with brown coal support the use of refuse derived fuel and solid recovered fuel as fuel on Hellenic Power Sector, adopting in the existing lignite power plants adequate Air Pollution Control systems. If the co-combustion or co-gasification of these alternative fuels is adopted from the Hellenic Power Sector a reduction on emissions is expected that cannot be neglected.


    加载中
    [1] Ionescu G, Rada EC, Ragazzi M, et al. (2013) Integrated municipal solid waste scenario model using advanced pretreatment and Waste to Energy processes. Energ Conser Manage 76: 1083-1092. doi: 10.1016/j.enconman.2013.08.049
    [2] Rada EC, Ragazzi M (2014) Selective collection as a pretreatment for indirect Solid Recovered Fuel generation. Waste Manage 34(2): 291-297.
    [3] European Environmental Agency (EEA), Europe's Environment, The Fourth Assessment, Copenhagen, 2007. Available from: http://www.eea.europa.eu/
    [4] EU Directive 1999/31/EC of 26 April 1999 on the landfill of waste. Available from: http://eur-lex.europa.eu/legal-content/EN/TXT/?uri=CELEX:31999L0031.
    [5] EU Directive 2000/76/EC of 4 December 2000 on the incineration of waste. Available from: http://eur-lex.europa.eu/legal-content/EN/TXT/?uri=CELEX:32000L0076.
    [6] EU Directive 2001/80/EC of 23 October 2001 on the limitations of emissions of certain pollutants into the air from large combustion plants. Available from: http://eur-lex.europa.eu/legal-content/EN/TXT/?uri=CELEX:32001L0080.
    [7] EU Directive 2001/77/EC of 27 September 2001 on the promotion of electricity produced from renewable energy sources in the internal electricity market. Available from: http://eur-lex.europa.eu/legal-content/EN/TXT/?uri=CELEX:32001L0077.
    [8] McDougall F, White P, Franke M, et al. (2001) Integrated Solid Wastes Management: A Life Cycle Inventory, Blackwell Publishing.
    [9] Rada EC, Andreottoala G (2012) RDF/SRF which perspective for its future in EU. Waste Manage 32(6): 1059-1060.
    [10] Van Tubergen J, Glorius T, Waeyenbergh E, Classification of Solid Recovered Fuels, European Recovered Fuel Organisation, 2005. Available from : http://erfo.info/fileadmin/user_upload/erfo/documents/classification/Classification_report.270205.pdf.
    [11] Archer E, Baddeley A, Klein A, et al. (2005) Mechanical-Biological-Treatment: A Guide for Decision Makers Processes, Policies and Markets (Juniper Consultancy Services Ltd.)
    [12] European Commission - Directorate General Environment, Refuse Derived Fuel, Current Practice and Perspectives (B4-3040/2000/306517/Mar/E3), Final Report, 2003. Available from: http://ec.europa.eu/environment/waste/studies/pdf/rdf.pdf.
    [13] Facts and Figures, European Recovered Fuel Organisation (Erfo). Available from : http://erfo.info/fileadmin/user_upload/erfo/documents/facts_and_figures/facts_and_figures_201205.rev3.doc.
    [14] Ragazzi M, Rada EC (2012) RDF/SRF evolution and MSW bio-drying. WIT T Ecol Environ 163: 199-208.
    [15] EN 15359 - Solid recovered fuels - Specifications and classes.
    [16] Kakaras E, Grammelis P, Agraniotis M, et al. (2005) Solid Recovered Fuels as Coal Substitute in the Electricity Generation Sector. Thermal Sci J 9: 17-30. doi: 10.2298/TSCI0502017K
    [17] Koukouzas N, Katsiadakis A, Karlopoulos E, et al. (2008) Co-gasification of solid waste and lignite - A case study for Western Macedonia. Waste Manage 28: 1263-1275. doi: 10.1016/j.wasman.2007.04.011
    [18] Hilber T, Maier J, Scheffknecht G, et al. (2007) Advantages and possibilities of solid recovered fuel co-combustion in the European energy sector. J Air Waste Manag Assoc 57(10): 1178-1189.
    [19] Garg A, Smith R, Hill D, et al. (2007) Wastes as co-fuels: the policy framework for solid recovered fuel (SRF) in Europe, with UK implications. Environ Sci Technol 41(14): 4868-74.
    [20] Samolada MC, Zabaniotou AA (2014) Energetic valorization of SRF in dedicated plants and cement kilns and guidelines for application in Greece and Cyprus. Resour, Conserv Recycling 83: 34-43. doi: 10.1016/j.resconrec.2013.11.013
    [21] Kara M (2012) Environmental and economic advantages associated with the use of RDF in cement kilns. Resour, Conserv Recycling 68: 21-28
    [22] Consonni S, Giugliano M, Grosso M (2005) Alternative strategies for energy recovery from municipal solid waste: Part A: Mass and energy balances. Waste Manage 25(2): 123-135
    [23] Ragazzi M, Rada EC, Panaitescu V, et al. (2007) Municipal solid waste pre-treatment: A comparison between two dewatering options. WIT T Ecol Environ 102 : 934-949.
    [24] European Commission, Integrated Pollution Prevention and Control, Reference Document on “Best Available Techniques for the Waste Incineration”, 2006. Available from: http://ec.europa.eu/environment/ippc/brefs/wi_bref_0806.pdf.
    [25] Marsh R, Griffiths AJ, Williams KP, et al. (2007) Physical and thermal properties of extruded refuse derived. Fuel Process Technol 88 : 701-706.
    [26] Consonni S, Vigano F (2011) Material and energy recovery in integrated waste management systems: The potential for energy recovery. Waste Manage 31(9-10): 2074-2084.
    [27] Theochari Ch, Aravossis K, Varelidis P, et al. (November 2006) Solid waste management in Greece - The Attica case, Technical Chamber of Greece, Athens, Final Report.
    [28] Hernandez-Atonal FD, Ryu C, Sharifi VN, et al. (2007) Combustion of refuse-derived fuel in a fluidised bed. Chem Eng Sci 62: 627-635. doi: 10.1016/j.ces.2006.09.025
    [29] RECOFUEL (2004) TREN/04/FP6EN/S07.32813/503184. Available from: http://www.eu-projects.de/recofuel.
    [30] CERTH/ISFTA (2002) Co-gasification of coal and wastes for power generation, THERMIE-SF/08/98/DE, Final Report.
    [31] Bilitewski B (2007) Incineration of Refuse Derived Fuel - Development, problems and chances, Proc. Int. Conf. Envir. Manag. Eng. Plan. Econ. (CEMEPE), Skiathos, Greece, 1543-1548.
    [32] Psomopoulos CS, Bourka A, Themelis NJ (2009) Waste to energy: A review of the status and benefits in U.S.A.. Waste Manage 29: 1718-1724. doi: 10.1016/j.wasman.2008.11.020
    [33] Tillman DA, Duong D, Miller B (2009) Chlorine in Solid Fuels Fired in Pulverized Fuel Boilers — Sources, Forms, Reactions, and Consequences: a Literature Review. Energ Fuel 23(7): 3379-3391
    [34] Chyang CS, Han YL, Wu LW, et al. (2010) An investigation on pollutant emissions from co-firing of RDF and coal. Waste Manage 30(7): 1334-1340.
    [35] Grammelis P, Kakaras E, Skodras G (2003) Thermal exploitation of wastes with lignite for energy production. J Air Waste Manag Assoc 53(11): 1301-11.
    [36] Ozkan A, Banar M (2010) Refuse derived fuel (RDF) utilization in cement industry by using Analytic Network Process (ANP). Chem Eng T 21: 769-774.
    [37] Wagland ST, Kilgallon P, Coveney R, et al. (2011) Comparison of coal/solid recovered fuel (SRF) with coal/refuse derived fuel (RDF) in a fluidised bed reactor. Waste Manage 31(6): 1176-1183
    [38] Greek Association of Communities and Municipalities in the Attica Region (ACMAR), 2009. Project: Composition and physicochemical properties of MSW of Attica 2006-2008. Presentation in Environmental Protection Committee of The Greek Parliament, January 29, Athens, Greece.
    [39] Eurostat, Municipal waste generation and treatment, by type of treatment method, 2014. Available from: http://epp.eurostat.ec.europa.eu/tgm/refreshTableAction.do?tab=table&plugin=1&pcode=tsdpc240&language=en.
    [40] Envitec SA (2004) The MSW Recycling and Composting Plant in Ano Liosia, Information brochure.
    [41] Economopoulos P (2004) Methodology for Development of an Optimized Waste Treatment Plan in the Attica Region, Presentation Technical Chamber of Greece.
    [42] Economopoulos AP (2007) Technoeconomic aspects of alternative municipal solid wastes treatment technologies, Proc. Int. Conf. Envir. Manag. Eng. Plan. Econ. (CEMEPE), Skiathos, Greece, 1731-1736.
    [43] http://www.wtert.gr, (accessed March, 2014)
    [44] Statistical Data About Solid Waste Treatment in Greece, Ministry of Environment, Department of Environmental Planning, Section of Solid Waste Treatment: Record Nr. 109947/3120, December 2004
    [45] Tsatsarelis Th, Karagiannidis A (2008) Evaluation of refuse derived fuel production and consumption potential in Greece, Proc. 2nd Int. Conf. Eng. Waste Valorisation, Patra, Greece, 1-8.
    [46] Lee SH, Themelis NJ, Castaldi MJ (2007) High-Temperature Corrosion in Waste-to-Energy Boilers. J Thermal Spray Techn 16(1): 1-7
    [47] Persson K, Brostrom M, Carlsson J, et al. (2007) High temperature corrosion in a 65MW waste to energy plant, Fuel Proc Tech 88: 1178-1182.
    [48] Vainikka P, Bankiewicz D, Frantsi A, et al. (2011) High temperature corrosion of boiler waterwalls induced by chlorides and bromides. Part 1: Occurrence of the corrosive ash forming elements in a fluidised bed boiler co-firing solid recovered fuel. Fuel 90(5): 2055-2063.
    [49] Bankiewicz D, Vainikka P, Lindberg D, et al. (2012) High temperature corrosion of boiler waterwalls induced by chlorides and bromides - Part 2: Lab-scale corrosion tests and thermodynamic equilibrium modeling of ash and gaseous species. Fuel 94: 240-250
    [50] Themelis NJ (2008) Older and Newer Thermal Treatment Technologies from a Reaction Engineering, IT3, Montreal, Canada.
    [51] Psomopoulos CS, Venetis I, Themelis NJ (2014) The impact from the implementation of Waste to Energy to the economy. A macroeconomic approach for the trade balance of Greece. Fresen Environ Bull, 23(11) in press.
  • Reader Comments
  • © 2014 the Author(s), licensee AIMS Press. This is an open access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0)
通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索

Metrics

Article views(8815) PDF downloads(1552) Cited by(17)

Article outline

Figures and Tables

Figures(7)  /  Tables(7)

Other Articles By Authors

/

DownLoad:  Full-Size Img  PowerPoint
Return
Return

Catalog